back to AMGBA website home page or AMGBA Photo Gallery or AMGBA Club Blog
Subscribe in a reader


Join or renew today and receive a free t-shirt or tech CD, see details in the join the club section at www.mgclub.org!

Author Topic: Rear end noise  (Read 5651 times)

0 Members and 1 Guest are viewing this topic.

may2008

  • Message Board Member not current AMGBA Club Member
  • **
  • Posts: 12
Rear end noise
« on: April 29, 2008, 09:12:24 PM »
I have noticed that when I shift gears, frequently there is a little chirp that seems to be coming from the rear end. There isn't any other rear end noise that I can identify as being out of the ordinary but that isn't saying much. Can you offer any ideas on what may be going on and what I might want to check to correct this problem.
 
Thanks again for your assistance.
 
Larry Tallman

amgba

  • American MGB Association
  • AMGBA Club Administrator
  • *****
  • Posts: 543
  • American MGB Association
    • American MGB Association
Re: Rear end noise
« Reply #1 on: April 29, 2008, 09:20:40 PM »
On the noise from the rear, I suspect the fiber thrust washers in the differential have either worn or dropped out completely.  The thrust washers are available from Moss (P/N 265-270, $9.40 each) and you need 2, one for each of the pinion gears.
 
Very common on MGBs, the fiber washers wear to the point that they are thin and brittle, break and fall into the bottom of the differential housing leaving excessive clearances between the differential pinion gears and the housing,  The classic "clunk" occurs when either dropping-off or pressing the accelerator, like when shifting. 
 
Replacement is involved, but not terribly difficult.  If you want to get an idea of the job, Mark Evans (Discovery Real Time - "An MG Is Born") did this job himself in building-up a 73 MGB, though I suspect much of the work was done off-camera.  You can probably do it yourself or get most any axle or transmission shop to put replacements in. I have no idea the cost, but can tell you my local trans shop gave me a $150 discount coupon toward rebuilding a differential.  If that's the discount I can't wait to see the full price.
 
I hope that helps you.  Let me know what you find.  Good luck.
 
Best always,
 
Art
 
American MGB Association
website: www.mgclub.org
email: info@mgclub.org
ph.: 773-769-7084
fax: 773-769-3240

North America's oldest and largest club for all MGBs, MGB-GTs & Midgets.  A nonprofit organization founded in 1975 and offers color magazines, emagazines, technical advice, member recommendations on service shops, registration of your MG, a tradition of service & FREE member classified ads that appear in the magazine & on the website.


 

   back to AMGBA website home page or AMGBA Photo Gallery or AMGBA Club Blog